Drag site icon to your taskbar to pin site. Learn More

2008 Honda CRF450R & CRF250R

Thursday, September 6, 2007
2008 CRF450R
The Honda Progressive Steering Damper is the first of its kind to be offered on a modern production 4-stroke.
Remember when Ricky Carmichael decimated the entire AMA professional ranks by sweeping every single moto in the 2004 outdoor National series? How couldn't you, it was only the biggest ball-stomping performance in the history of our sport - and his second two-dozen sweep. RC first did it in 2002 on a Honda CR250R and then lost a couple motos but swept the 12 overalls in 2003 before going perfect again in '04. What does that all have to do with the 2008 CRF-R lineup from Big Red? That's when the development process began for Honda's big '08 unveiling.

There're a few noteworthy changes to the CRF450R and CRF250R this year, but nothing as big as the introduction of the Honda Progressive Steering Damper (HPSD). Once thought of as an accessory for the off-road crowd, factory motocross teams have understood the benefits of running a damper for years - all of which have been tucked neatly out of sight. Aftermarket dampers are usually large, bulky contraptions that bolt onto the steering head and mount on or under the handlebar crossbar. Big Red has come up with a much smaller, 6.5-ounce system that attaches behind the front number plate, bolted to the re-worked steering head and lower triple clamp.

The addition of the HPSD allows for changes to the steering geometry. New triple clamps drop from 24mm to 22mm of offset which adds 2mm of trail and shortens the wheelbase by the same amount. Honda claims the bike turns quicker and with more stability thanks to the combined changes. Here's how it works.

Once the triple clamp moves beyond five degrees either direction off of center-line, the damping effect comes into play. Damping is stiffer as the unit moves away from center, but a position-sensitive circuit opens to allow for easier return to center. Also, much like a Scott steering damper, the HPSD system is speed-sensitive as well, which means the damping effect is minimal while turning at low speeds but stiffens considerably with a sudden jerk. This means that when the front end tags a square-edged hole and wants to rip out of your hands, the HPSD eases the violent jolt. However, correcting the damage and getting straightened out is doesn't require the rider to force the bars back into position.

2008 CRF450R
The 2008 Honda CRF450R gets a bunch of little updates to accompany the HPSD system - and it's supposed to be a couple pounds lighter than the 2007.
Much like the fork that straddles it, the HPSD has 15 levels of adjustability and is rebuildable. Being able to control the damping speed will give riders another option when tailoring their suspension and handling characteristics. Honda claims that during testing, the damper allows riders to stiffen the bike's suspension because there is less jarring, deflection and movement from the front end. Whether this is true or not will be decided once we get to throw a leg over the '08 CRF models, but the implications of sharper, more stabile cornering and better straight-line performance make the HPSD one of the most intriguing upgrades of 2008.

The 450R also gets another piece of works hand-me-down technology. A multi-map CDI controls ignition mapping based on gear selection. Individual maps for first, second and third-fifth help control power delivery. A tapered exhaust header is supposed to boost low- and mid-range power while the top-end is supposed to rev out 50 extra rpm to a claimed 11,270. Honda claims 55 bhp at 9K rpm and 36.9 lb-ft. of torque at 6500. Honda also offers a usable weight figure - one that includes all equipment, required fluids and a full 1.9 gallons of fuel! Its figure of 238 is a couple pounds shy of our 2007 test bike which was a tad over 240. Perhaps those extra savings come from a new set of petal-style rotors - still 240mm each, but with those fancy ripples.

Suspension has been addressed as well with a larger cartridge rod and new oil in the 47mm Showa fork as well as stiffer springs. Revalving was in order and the shock was adjusted as well.

2008 CRF450R
Both the 250R and 450R get new triple clamps that feature 22mm of offset rather than 24. New steering geometry is supposed to make the bikes more agile than ever.
2008 Honda CRF450R Specs:
Engine Type: 449cc liquid-cooled single-cylinder 4-stroke
Bore and Stroke: 96mm x 62.1mm
Compression Ratio: 12.0:1
Valve Train: Unicam, four-valve; 36mm intake, titanium; 30mm exhaust, steel
Induction: Carburetor, Keihin 41mm flat slide
Ignition: CD with three-gear-position electronic advance
Transmission: Close-ratio five-speed
Final Drive: #520 chain; 13T/48T
Fork: 47mm inverted Showa cartridge fork with 16-position rebound and 16-position compression damping adjustability; 12.4 inches travel
Shock: Pro-Link Showa single shock with spring preload, 17-position rebound damping adjustability, and compression damping adjustment separated into low-speed (13 positions) and high-speed (3.5 turns); 12.5 inches travel
Front Brake: Single 240mm disc with twin-piston caliper
Rear: Single 240mm disc
Front Tire: 80/100-21
Rear: 110/90-19
Wheelbase: 58.6 inches
Rake (Caster Angle): 26.76
Trail: 111.4 mm (4.3 inches)
Seat Height: 37.6 inches
Ground Clearance: 13.4 inches
Fuel Capacity: 1.9 gallons
Color: Red / Black
Curb Weight: 238 pounds (Includes all standard equipment, required fluids and full tank of fuel-ready to ride)

2008 Honda CRF250R

2008 CRF250R
A slightly higher compression ratio is just the tip of the iceberg with the CRF250R's list of minor engine mods.
The quarter-liter thumper also gets the HPSD, 22mm offset triple clamps, three-way ignition mapping, fork and shock adjustments, works-style brake rotors and new rear fender shape. Specific to the machine are a myriad of engine adjustments. A new piston jumps the compression ratio to 13.1:1 compared to '07's 12.9:1, and moves underneath a cylinder head with new porting. Lighter valve train components, counterbalancer shaft and drive gears and revised cam timing all add to a claimed increase in power. The 40mm Keihin FCR carburetor has new settings to smooth out the delivery and the exhaust system is reworked.

Honda claims this one is ready to ride at 227 pounds which is one pound heavier than our 2007 unit. Neither machine has a listed MSRP for the time being.

2008 CRF250R Specs:
Engine Type: 249cc liquid-cooled single-cylinder 4-stroke
Bore and Stroke: 78mm x 52.2mm
Compression Ratio: 13.1:1
Valve Train: Unicam, four-valve; 31mm intake, titanium; 26mm exhaust, steel
Induction: Carburetor, Keihin 40mm flat-slide with throttle position sensor (TPS)
Ignition: CD with electronic advance
Transmission: Close-ratio five-speed
Final Drive: #520 chain; 13T/51T
Fork: 47mm inverted Showa cartridge fork with 16-position rebound and 16-position compression damping adjustability; 12.4 inches travel
Shock: Pro-Link Showa single shock with spring preload, 17-position rebound damping adjustability, and compression damping adjustment separated into low-speed (13 positions) and high-speed (3.5 turns); 12.4 inches travel
2008 CRF250R
The dual-exhaust is still there, but Honda has revised it enough to call it new.
Front Brake: Single 240mm disc with twin-piston caliper
Rear: Single 240mm disc
Front Tire: 80/100-21
Rear: 100/90-19
Wheelbase: 58.2 inches
Rake (Caster Angle): 27.9
Trail: 125mm (4.9 inches)
Seat Height: 38 inches
Ground Clearance: 14.2 inches
Fuel Capacity: 2.0 gallons
Color: Red / Black
Curb Weight: 227 pounds (Includes all standard equipment, required fluids and full tank of fuel-ready to ride

Let us know what you think about the 2008 Honda CRFs in the MotoUSA Forum.
2008 Honda CRF450R & CRF250R Gallery
View Gallery
View Gallery
View Gallery
View Gallery
View Slideshow
Other Dirt Bike First Looks
2016 KTM XC-W Models First Looks
KTM gives its 2016 XC-W line upgrades aimed at reducing weight and enhancing off-road protection and performance. Also back and better than ever is KTM's genre-bending two-stroke, the Freeride 250 R.
2016 KTM 500 EXC   350 EXC First Looks
KTM updates its popular 500 EXC and 350 EXC dual-sport motorcycles for 2016, reducing weight and offering improved off-road protection.
2016 KTM Motocross SX-F First Looks
KTM reveals complete overhauls of its 2016 MX lineup, with the 450, 350 and 250 SX-F models featuring changes that debuted on the 2015 Factory Editions.
Honda Dirt Bike Dealer Locator

Login or sign up to comment.

Paul -2008 Crf450r  October 17, 2010 08:34 AM
Awesome bike!!!.Would never get rid of mine.
Leeroy -Serial numbers?  April 13, 2010 08:39 PM
Hi, I was just wondering, I purchased a 2008 CRF250r. Unfortunatley some idiots came and stole it while I was on holidays. Could anyone tell me where the frame and engine serial numbers are located on the bike? I have found a couple bikes like mine that are up for sale on a local online website and I'm going to go and check them out. Any help woul dbe greatly appreciated
TexasRider -in love with my bike  April 3, 2010 03:10 PM
I just bought a 2008 CRF250 (my first thumper) and it is hands down the best bike I have ever owned. Easy to start, AWESOME suspension, and just an overall well built bike. I am sorry about the last eight years I spent on the other guys bikes Honda. Were back in the RED !
T-Mart -CRF250R  March 25, 2010 06:14 AM
I love my bike its awesome its really fast and runs great
joey jones -crf 250R  February 12, 2010 11:27 AM
my CRF250Ris a 2004 and i think that we should go back to that design because it better than the honda 250s today its more tourky and faster and top end
nate -2008 250  January 3, 2010 10:28 PM
i have owned 3 hondas two crf 250 and a 450 love the bikes but valves are junk, and i think honda needs to figure something out.
bj -crf 250r  October 5, 2009 02:39 PM
the valves are garbege on the crf250r 06 07 my bikes through the valves twice and the i decided to use aftermarket wisco valvs and their ausom. I love my hondas to death but 'sorry the valves were garbege for thoes two years for all i know. And i know!
dj jd -my bike  July 19, 2009 11:10 AM
im 16 and 6ft 5 and feel that is bike is the best. i love my 08 crf450r.

ASV RACING -450  July 7, 2009 10:57 AM
Michael Bethea -Damn  May 26, 2009 09:25 AM
i think CRF 250 and 450s are awsome fast light and sooo much torque! Ride HONDA cuz its awsome
garrett -dirt bike  May 22, 2009 05:06 PM
i love to go off road with 4-whelers and dirt bikes......i think yull should have a contest for free dirt bikes....geargia......ialso like geting stuck in mmuudd its all i ever do......CB country boy.......SB suther boy......love the rebal flag....it aint comin down
Esundy -Awesome year!  May 19, 2009 12:05 PM
I have heard nothing but great reviews from everyone I know that owns an '08 CRF450 and I used to work for a Honda dealership, so I ran into a lot of proud owners.
Dave - Groover -Honda CRF250R  May 18, 2009 11:42 AM
I am 45, livng in South AFrica and have mostly been riding Enduro bikes; Husky 360,250 KTM 250 EXC over the last 9 years and let me tell you I feel like I am cheating when I ride my RED,I get air like never before and landing ...well I just cant seem to get it wrong...and as for the "out there" riding...bring it on....
kyle -production numbers  April 16, 2009 08:22 PM
i was just wondering if you guys know how many of these bikes were actually made. my serial number is #9 just curious thanks
jdog -badass  April 16, 2009 11:21 AM
dude this bike is badass i finally cleared a 100 foot triple on mine